Nissan Note windshield size: how to choose and replace without mistakes

Windshield Nissan Note - a critical element of safety, which affects not only visibility, but also body rigidity in an accident. However, in the event of damage (cracks, chips) or planned replacement, owners are faced with a problem: how to select glass to the exact dimensions to avoid leaks, squeaks and installation problems?

In this article we will look at standard windshield sizes for all generations Nissan Note (E11, E12), including options with heating and rain sensors. You will learn how take your own measurements correctly, which brands offer high-quality analogues of the original, and why cheap glass from China can result in expensive body repairs. We will also reveal the nuances of replacement: from preparing the glue to checking the tightness after installation.

Standard windshield sizes for Nissan Note by generation

Windshield sizes depend on generation and configuration Nissan Note. Official manufacturer data indicates two main sizes:

• 📏 Nissan Note E11 (2004–2012) — 1350 × 950 mm (height × width). Suitable for most modifications, including versions with and without air conditioning.
• 📏 Nissan Note E12 (2012–2020) — 1360 × 960 mm. The increased dimensions are associated with changes in body design and the angle of the glass.
• ⚡ Important! Cars with option HUD (Head-Up Display) or light/rain sensor require glass with a special projection area (usually marked HUD Ready).

Below is a table with the exact dimensions and catalog numbers of the original glasses:

Generation	Size (H×W), mm	Original article	Notes
E11 (2004–2009)	1350 × 950	28510-4M000	Without heating, standard tinting
E11 (2009–2012, restyling)	1350 × 950	28510-4M001	With rain sensor area
E12 (2012–2016)	1360 × 960	28510-4M100	With heating and acoustic film
E12 (2016–2020, restyling)	1360 × 960	28510-4M101	With option HUD and improved sound insulation

⚠️ Attention: Even within the same generation, sizes may vary slightly due to configuration. For example, glass for versions with a panoramic roof (Nissan Note Acenta) have a different bend at the top. Always check the article number against VIN-code through services like Nissan TechInfo.

How to measure your windshield yourself: step-by-step instructions

If you are not sure of the sizes or are buying glass from hand, it is better to take the measurements yourself. For this you will need:

• 📏 Tape measure or ruler ≥ 1.5 m long (it is better to use a flexible meter).
• 🧲 Magnetic square for checking right angles.
• 📝 Notepad for notes (it is important to record not only the dimensions, but also the bending radius).

Measurement algorithm:

1. Measure width glass along the bottom edge (from left to right corner). Please note that the actual width may differ from the stated width by 5–10 mm due to the seal.
2. Measure height from the bottom edge to the top point (center). For Nissan Note E12 It is better to measure the height in three places: in the center and along the edges - the bend of the glass may be asymmetrical.
3. Check radius of curvature. To do this, apply a ruler to the glass diagonally: a gap of more than 3 mm indicates a non-standard bend.

Accurate measurements taken (width × height × radius)

Article confirmed by VIN code

Equipment taken into account (rain sensor, HUD, heating)

The seller's reputation has been checked (reviews, guarantee)

Prices compared in 3–4 stores -->

⚠️ Attention: If there is a crack in the glass, do not try to measure along the edges - the distortion may skew the results. It is better to use the data from the technical documentation or contact an authorized dealer Nissan.

Original vs analogues: which glass brands to choose for Note

Original glass from Nissan (production AGC or NSG) guarantee a perfect fit and compatibility with electronics, but their price often exceeds 20,000 rubles. An alternative is glass from trusted brands:

• 🔹 Pilkington - British manufacturer, supplier to many automakers. Glasses with markings OEM Quality identical to the original, but 30–40% cheaper.
• 🔹 Saint-Gobain Sekurit - a French brand with a factory in Russia. They are distinguished by increased strength and sound insulation (series Acoustic).
• 🔹 XYG (China) - a budget option (from 8,000 rubles), but the quality varies. The risk of defects is up to 15%, so buy only from trusted suppliers with a guarantee.
• 🔹 Guardian - American brand, glass with improved optics (less glare at night).

Comparison of key parameters:

Brand	Price, ₽	Noise insulation	HUD Compatible	Warranty
Nissan (original)	20 000–25 000	⭐⭐⭐⭐⭐	Yes	2 years
Pilkington	12 000–15 000	⭐⭐⭐⭐	Yes (OEM series)	1 year
Saint-Gobain Acoustic	14 000–18 000	⭐⭐⭐⭐⭐	Yes	1.5 years
XYG (China)	8 000–10 000	⭐⭐	No (exceptions - special series)	6 months

💡 Advice: When purchasing an analogue, be sure to check whether the glass is certified according to the standard ECE R43 (marking in the corner of the glass). Without this certificate, the glass may not pass technical inspection.

Substitution subtleties: errors that spoil the result

Even perfectly selected glass can cause problems if the installation technology is incorrect. Common mistakes:

• 🚫 Saving on glue. Cheap sealants (for example, Abro) lose elasticity after 1–2 years, which leads to leaks. For Nissan Note recommended Teroson PU 6860 or SikaTack Drive.
• 🚫 Incorrect body preparation. Old adhesive residue or rust on the glass frame will reduce adhesion. Be sure to use primer (primer) for metal.
• 🚫 Violation of polymerization time. The minimum drying time for glue is 4 hours (at +20°C). If you go earlier, the glass may move.
• 🚫 Ignoring camera calibration. After replacing the glass with Nissan Note E12 with the system ProPilot Recalibration of the front camera is required (cost ~3,000 ₽).

🔧 Step-by-step replacement algorithm:

1. Remove the wipers, plastic trim and glass seal.
2. Cut out the old glass with a special string (do not use a knife - you will damage the varnish!).
3. Clean the frame from glue and rust, treat with primer.
4. Apply glue to the glass and body (layer thickness - 8-10 mm).
5. Install the glass, securing it with tape for 2-3 hours.
6. Do not wash the car or open the doors for 24 hours (excessive pressure may dislodge the glass).

What to do if, after replacement, a whistle appears at speed?

Whistling at speeds >80 km/h is usually caused by loose glass in the upper corners. Solution:

1. Check the uniformity of the adhesive seam (it should be the same thickness around the entire perimeter).

2. If the whistle appears immediately, the glass has the wrong radius. Replacement required.

3. If the whistle occurs after a while, the glue has lost its elasticity. The glass needs to be re-glued with new sealant.

How much does it cost to replace a windshield on a Nissan Note?

The cost of work varies depending on the region and type of glass:

• 💰 Official service Nissan: 15,000–25,000 ₽ (includes original glass + labor + 2-year warranty).
• 💰 Independent auto glaziers: 8,000–12,000 ₽ (with analogue from Pilkington or Saint-Gobain).
• 💰 Mobile services: 6,000–10,000 ₽ (without removing the seals, the risk of leaks is higher).
• 💰 Self-replacement: 3,000–5,000 ₽ (cost of glass + glue + tools).

📌 Hidden costs:

• Camera calibration (Nissan Note E12 with Safety Shield) — 2 500–4 000 ₽.
• Replacement of glass seal - 1,500–2,000 RUR (if the old one is torn or has lost elasticity).
• Repair of chips before replacement (if the crack originates from a chip) - 1,000–3,000 ₽.

⚠️ Attention: CASCO insurance policies often omit the clause on glass replacement coverage. Check with your insurer to see if your windshield is considered a "consumable item" - in which case repairs will not be covered.

💡

Saving on glue or body preparation costs more: water leaks lead to corrosion of electronic components (for example, ECU), repairs of which cost from 30,000 ₽.

How to extend the life of your windshield: preventing cracks

The average lifespan of a windshield is 5-7 years, but with proper care it can be extended to 10 years. Key recommendations:

• 🚗 Pressure washing. Do not direct the water stream at the edge of the glass - this will destroy the sealant. Use a diffuser nozzle.
• ☀️ Parking in summer. Avoid prolonged exposure to sunlight (temperature differences between the center and edges of the glass lead to microcracks). Use sunscreen.
• ❄️ Winter operation. Do not pour boiling water onto frozen glass - a sharp temperature change will cause chips. Use special defrosters.
• 🛠️ Repair of chips. Even a small chip with a diameter of 5 mm can turn into a crack 30 cm long in a week. The cost of repairing a chip is 500–1,500 rubles, replacing glass is from 10,000 rubles.

🔬 Strength test: If “cobwebs” (small cracks without visible damage) appear on the glass, check its strength. To do this, lightly tap the edge of the glass with a coin. A dull sound indicates delamination of the triplex - such glass needs to be urgently replaced.

FAQ: Frequently asked questions about Nissan Note windshield

Is it possible to install glass from a Nissan Micra on a Note?

No, despite the external resemblance, glass Nissan Micra K13 And Note E12 They have different bending radii and mountings for wipers. Installation of glass from Micra will lead to leaks and squeaks.

What glue is best to use for DIY replacement?

For Nissan Note Two-component polyurethane adhesives are optimal:

• Teroson PU 6860 — polymerization time 4 hours, can withstand up to +120°C.
• SikaTack Drive — suitable for heated glass, does not lose elasticity at -30°C.
• 3M Urethane Adhesive - expensive, but guarantees tightness for 10+ years.

❌ Do not use silicone sealants - they do not provide the necessary strength.

What should I do if the rain sensor does not work after replacement?

The problem in 90% of cases is due to incorrect connection of the sensor connector. Check:

1. Glass compliance (there must be a zone for the sensor with markings Rain Sensor).
2. Integrity of wiring (often damaged when removing old glass).
3. Settings BCM (sometimes it is necessary to reset errors through a diagnostic scanner).

If the sensor is working, but not calibrated, contact an authorized dealer for firmware update ECU.

How long does it take to replace glass?

In the service, the procedure takes 2–3 hours, but complete polymerization of the glue occurs in 12–24 hours. At this time you cannot:

• Wash the car.
• Drive at speeds >60 km/h (excessive air pressure may dislodge the glass).
• Slam doors (vibration disrupts adhesion).

Is it possible to drive with a crack in the windshield?

Cracks are prohibited by law in Russia:

• Length >10 cm in the wiper operating area.
• Any cracks that distort the driver’s view (fine - 500 rubles under Article 12.5 of the Administrative Code).

In addition, a crack reduces the strength of the glass by 70% - in the event of an accident, it may delaminate and not hold the roof of the body.